公司新聞

攤鋪機出租后使用的操作規程

來源：http://www.gaohufs.com/ 日期：2022-08-17

如今路面施工的速度在“飛速”的提高，在施工工藝和路面材料及路面結構設計提出了越來越高的要求。那么濟南攤鋪機出租后使用的操作規程是怎樣的呢?

Nowadays, the speed of pavement construction is increasing rapidly, which puts forward higher and higher requirements for construction technology, pavement materials and pavement structure design. What are the operating procedures for the use of Jinan pavers after they are rented?

一、攤鋪機操作人員須經過專業培訓，了解機械性能、構造，掌握保養知識，熟練地掌握本機性能及操作要領和安全事項，并經有關部門確認合格后，方可單獨操作。

1、 The paver operators must receive professional training, understand the mechanical performance and structure, master the maintenance knowledge, master the performance, operation essentials and safety matters of the machine, and operate independently after being confirmed as qualified by relevant departments.

二、起動發動機前須檢查：油(機油、燃油、工作油、潤滑油)量是否足，風扇上皮帶松緊度，有無漏油及其部件松動現象。檢查當天工作所需的各種配件、附件、工具等是否齊備。

2、 Before starting the engine, check whether the oil (oil, fuel, working oil and lubricating oil) is sufficient, whether the belt on the fan is tight, whether there is oil leakage and whether the parts are loose. Check whether various accessories, accessories and tools required for the work of the day are complete.

三、起動發動機后，怠速運行至少兩分種后檢查各監控系統指示是否正常。

3、 After starting the engine, check whether the indication of each monitoring system is normal after idling for at least two minutes.

四、運料車輛倒料須有人指揮，準確將料卸入機器料斗內。

4、 The unloading of the material transport vehicle must be commanded by someone to accurately discharge the material into the hopper of the machine.

五、攤鋪機工作前須和左右調平人員取得聯系，確保其他人員不在作業內，方可作業。

5、 Before the paver works, contact the left and right leveling personnel to ensure that other personnel are not in the operation.

六、在作業檔向行車走檔轉換時，須在小油門，機器完全停穩后，各工作部件停止工作情況下進行。

6、 When shifting from the operating gear to the driving gear, it must be carried out when the accelerator is small and the machine is completely stopped and all working parts stop working.

七、操作人員嚴禁酒后操作，操作設備時須穿戴整齊，不得穿拖鞋，不得有吸煙、飲食等其他有礙安全作業行為。

7、 Operators are not allowed to operate after drinking. They must wear neat clothes when operating the equipment. They must not wear slippers. They must not smoke, eat or drink and other behaviors that hinder safe operation.

八、攤鋪機在工作后，所有防護裝置須安裝在指定位置上。

8、 After the paver is in operation, all protective devices shall be installed at the designated positions.

九、操作室(臺)須保持清潔，及時清理油污等污物，不得亂放工具等其他物品。

9、 The operating room (platform) shall be kept clean, and the dirt such as oil stain shall be cleaned in time. Tools and other items shall not be placed randomly.

十、司機離開操作臺前，須將操作機構全部置于“0”位上。

10、 Before leaving the operating platform, the driver must put all the operating mechanisms at the "0" position.

十一、對于液壓自動加寬攤鋪機加寬時，須注意和觀察附近情況，以免傷人和損壞設備。

11、 When the hydraulic automatic widening paver is widened, it is necessary to pay attention to and observe the surrounding conditions to avoid hurting people and damaging equipment.

十二、當攤鋪在使用液化氣罐加熱時，在熄火或失火等情況，須將罐閥關閉。當環境溫度高于200C或太陽直曬車氣罐時使用氣罐加熱，氣罐須加以遮蓋。

12、 When the paving is heated with liquefied gas tank, the tank valve must be closed in case of flameout or fire. When the ambient temperature is higher than 200C or the air tank of the direct sun drying vehicle is used for heating, the air tank must be covered.
濟南攤鋪機出租

十三、攤鋪結束后，清洗材料輸送、搗實裝置、停機時須把熨平板放置在墊木上，機器停放下不得妨礙交通，且應放置警示牌。發動機怠帶運行5分鐘再熄火，然后切斷電源，鎖上儀表盤。

13、 After paving, the screed shall be placed on the skid when cleaning the material conveying and tamping devices and stopping the machine. The parking of the machine shall not hinder the traffic, and warning signs shall be placed. The engine shall run idle for 5 minutes and then shut down, then cut off the power supply and lock the instrument panel.

十四、設備保養須按照說明書中的要求進行。

14、 Equipment maintenance shall be carried out according to the requirements in the manual.

十五、設備維修保養時，須：

15、 During equipment maintenance, it is required to:

(一)料斗、熨平板固定牢靠。

（1） The hopper and screed are firmly fixed.

(二)發動機熄火。

（2） The engine stalls.

(三)維修液壓系統時，須釋放液壓系統的余壓。

（3） When repairing the hydraulic system, the residual pressure of the hydraulic system must be released.

此外該設備的日常保養要做好，比如要定時清除攤鋪機表面堆積的泥塊、粘沙和瀝青等；清除發動機、液壓元件和其他部件表面上的塵土、油垢。注意，切勿將污物弄進各加油口和空氣濾清器內。更多注意事項就來我們網站http://www.gaohufs.com咨詢吧。

In addition, the daily maintenance of the equipment should be done well, such as regularly removing the mud, sand and asphalt accumulated on the surface of the paver; Remove the dust and oil dirt on the surfaces of the engine, hydraulic components and other components. Be careful not to get dirt into the fuel filler and air filter. For more information, please visit our website http://www.gaohufs.com Consult.

上一條：租用挖掘機可以給您帶來的好處

下一條：攤鋪機的維修保養和常見故障的排除